IKEA 594.003.98 GRILLSKÄR Kitchen Sink ut chrcl BBQ Instruction Manual
- June 4, 2024
- Ikea
Table of Contents
594.003.98 GRILLSKÄR Kitchen Sink ut charcoal BBQ
Instruction Manual
LIST OF FEATURES
The numbering of the product features shown refers to the illustration of the
side burner on the graphic page
- Top lid
- Burner
- Control knob
- Side burner body
WARNING
- For outdoor use only.
- Read these instructions before using the side burner. Failure to follow these instructions and safety warnings may result in serious bodily injury or death, and/or property loss.
- Warning: Accessible parts may be very hot. Keep children and pets away from the side burner.
- Do not attempt to move the side burner during use.
- Turn off the gas supply at the gas cylinder after use.
- Any modification of the side burner, misuse, or failure to follow the instructions may be dangerous and cause harm to you or others.
- Leak test the side burner before first use, annually, when dismantled, when parts are replaced, or if the gas cylinder is removed or replaced
- If installed by a third party, the installer must leave instructions with the consumer and the consumer must retain these instructions for future reference.
- GRILLSKÄR side burner is only to be used together with the GRILLSKÄR gas barbecue.
- When positioning, ensure the side burner is a minimum of 1 meter/40″ from flammable items or structures from the sides and back of the appliance.
- Do not install in, or connect to the consumer piping or gas supply system of a boat or caravan.
- DO NOT USE AN ADAPTOR AT THE CYLINDER CONNECTION.
SAFETY SYMBOLS
The safety symbols and their meanings are explained below. Read and follow the
instructions in this manual carefully.
DANGER
DANGER: Indicates an imminently hazardous situation that, if not avoided,
will result in death or serious injury.
WARNING
WARNING: Indicates a potentially hazardous situation that, if not
avoided, could result in death or serious injury.
CAUTION
CAUTION: Indicates a potentially hazardous situation or unsafe practice
which, if not avoided, may result in minor or moderate injury.
WARNING
Failure to read and follow these instructions could result in serious injury
or damage to property.
This product is for OUTDOOR USE ONLY.
Shall not be used in a building. NEVER use in an enclosed space such as a
carport, garage, veranda, covered patio, or under an overhead structure of any
kind.
Important – LEAK TEST ALL CONNECTIONS BETWEEN THE GRILLSKÄR BARBECUE AND THE
SIDE BURNER WHEN FULLY ASSEMBLED BEFORE FIRST USE. IN ADDITION always leak
test the side burner annually, when dismantled, when parts are replaced, or if
the gas cylinder is removed or replaced. FAILURE TO DO THIS COULD CAUSE
SERIOUS INJURY OR DAMAGE TO THE SIDE BURNER.
Always keep the cylinder vertical.
Important – Ensure the unit is positioned on flat, level ground to aid with
fat/grease runoff.
GRILLSKÄR side burner is designed for use with Universal LPG gas only. Do not
use natural (piped in-city) gas. The valves, orifices, hose, and regulator are
for Universal LPG only.
Should you need to change the gas cylinder, make sure the unit is switched
off, and that there are no sources of ignition (cigarettes, open flame,
sparks, etc.) nearby before proceeding.
Never use indoors, in an enclosed area or below ground level.
This side burner shall only be used above ground in an open-air situation with
natural ventilation, without enclosed areas, where gas leakage and products of
combustion are rapidly dispersed by wind and natural convection.
This side burner is not intended to be used in or on boats or in or on
recreational vehicles.
This side burner should not be used under overhead combustible construction.
Never use an adjustable regulator with this unit.
This side burner will become very hot when in use – take care when touching.
Keep children and pets at a safe distance from this side burner when in use.
Do not attempt to move this side burner when in use.
Always turn off gas supply at the gas cylinder when not in use.
Any modification of this burner may be dangerous.
Do not leave this side burner unattended when in use.
Any parts sealed by the manufacturer or his agent must not be altered by the
user.
When igniting, always have the lid open.
Only use the side burner on a flat, level nonflammable surface or ground.
When positioning, ensure the side burner is a minimum of 1 metre/ 40″ from
flammable items or structures from the sides and back of the appliance.
Before each use inspects the gas hose to ensure it is free of any twisting or
tension.
Do not obstruct the flow of combustion and ventilation air.
When storing the side burner or gas cylinder, ensure they are away from
flammable materials or liquids.
The gas cylinder must not be stored next to this or any other appliance. |
Always follow care and maintenance instructions – regularly maintain your side
burner.
Do not allow grease, fat or food residue to build up in or on the side burner
– RISK OF FIRE.
Always replace worn parts – do not use the side burner if a leak, wear or
damage is found.
Do not store or cover the side burner until fully cooled.
Keep the ventilation opening of the cylinder enclosure free and clear from
debris.
Keep the fuel supply hose away from any heated surface.
Keep the area around your gas side burner clear of any combustible materials,
petrol, or other flammable liquids and vapors.
The pressure regulator and hose assembly supplied with this barbecue/side
burner must be used.
Replacement pressure regulators and hose assemblies must be the same as those
supplied originally with the side burner.
Do not hang any combustible materials from the handrails of this barbecue/side
burner.
Accessible parts may be very hot. Keep young children away.
Always wear protective gloves or a barbecue mitt when handling hot components
or items such as pots.
A cooking vessel with a diameter of no less than 10cm (3.9″) and no greater
than 26cm (10″) should only be used.
Any enclosure in which the appliance is used shall comply with one of the following:
- An enclosure with walls on all sides, but at least one permanent opening at ground level and no overhead cover.
- Within a partial enclosure that includes an overhead cover and no more than two walls.
- Within a partial enclosure that includes an overhead cover and more than two walls, the following shall apply—
- At least 25% of the total wall area is completely open and
- At least 30% of the remaining wall area is open and unrestricted.
- In the case of balconies, at least 20% of the total of the side, back, and front wall areas shall be and remain open and unrestricted. Please see Fig F1-F5 at the back of this manual for examples.
DO NOT MODIFY THIS APPLIANCE.
Do not use petrol, white spirit, lighter fluid, alcohol, or other similar
chemicals to ignite a side burner.
DO NOT PLACE ARTICLES ON OR AGAINST THIS APPLIANCE
LEAK TESTS
IMPORTANT – PERFORM LEAK TESTS BEFORE USE
Always leak test the unit – annually, when dismantled, when parts are
replaced, or if the gas cylinder is removed or replaced.
- Never use an open flame to check for leaks at any time. DO NOT IGNITE THE SIDE BURNER DURING LEAK TESTING.
- To be performed in a well-ventilated area.
- Be sure all control knobs are in the ‘OFF’ position.
- Check for leaks by brushing a solution of 1/2 water and 1/2 soap over all the gas system joints, including all valve connections, hose connections, and regulator connections.
- Ensure the soap solution has been applied to all connections – connect the regulator to the gas cylinder, and open the gas control valve on the regulator allowing gas to flow.
- OBSERVE – if bubbles form over any part of the joints there is a leak.
- Turn off the gas and tighten all joints
- Repeat test. If bubbles form again, do not use the side burner. Please contact your local dealer for assistance.
GAS AND REGULATOR INSTRUCTIONS
- This side burner is only for use with cylinders marked Universal LPG.
- The cylinder should be positioned underneath the main barbecue body and stored upright.
- Gas cylinders should never be stored or laid on their side.
Before each use inspects the gas hose to ensure it is free of any twisting or tension.
User instructions
GRILLSKÄR side burner is only to be used together with the GRILLSKÄR gas
barbecue.
Before assembling your side burner, remove all protective packaging from each
part. Do not store a spare LP gas cylinder under or near this appliance.
Cylinder used must include a collar to protect the cylinder valve.
Never fill the cylinder beyond 80% full. Failure to follow these instructions
exactly may result in fire causing serious injury or death.
Place dust cap on cylinder valve outlet whenever the cylinder is not in use.
Only install the type of dust cap on the cylinder valve outlet that is
provided with the cylinder valve. Other types of caps or plugs may result in
the leakage of gas.
The gas cylinder must have a connection compatible with the regulator supplied
with the side burner and have a minimum capacity of 4kg / 9lbs.
SIDE BURNER USER INSTRUCTIONS
Before proceeding, make certain that you understand the warning statements in
this manual.
BEFORE USING THIS APPLIANCE
-
Please read all of these instructions and the appliance owner’s manual prior to installation and use.
-
FOR OUTDOOR USE ONLY!
• Appliance and tank must be in an open, well-ventilated outdoor area prior to connection and use. Make sure the tank valve is fully closed and not leaking prior to moving or connecting.
• NEVER USE IN A GARAGE OR UNDER OVERHANGS!
• NEVER STORE A SPARE CYLINDER OR ANY FLAMMABLE LIQUID OR GAS UNDER OR NEAR THIS APPLIANCE OR ANY OTHER HEAT SOURCE. -
Be sure the tank valve and regulator are proper mating types, with correct threads or fittings, see manual.
-
Inspect tank valve, regulator, hose and fittings to be sure they are clean, free of dirt, and debris, not plugged and not damaged. If damaged replace before use. See local LP dealer for repairs.
-
Prior to connection, turn all control valves to the OFF position.
-
Connect the regulator to the tank valve according to the appliance owner’s manual. Handle cylinder with care – the contents are under high pressure.
-
If a good connection has been made, slowly open the tank valve to fully open. Use a soapy water solution to check all gas connections for leaks before lighting appliance.
• NEVER TEST WITH OPEN FLAME!
• IF YOU SMELL GAS OR A LEAK IS FOUND:
• SHUT OFF GAS AT THE TANK VALVE IMMEDIATELY.
• EXTINGUISH ANY OPEN FLAME OR OTHER POTENTIAL IGNITION SOURCE.
• DO NOT USE APPLIANCES UNTIL REPAIRS ARE MADE BY A QUALIFIED LP GAS DEALER.
• DO NOT ATTEMPT TO MAKE REPAIRS YOURSELF!
• DO NOT USE ANY APPLIANCE, OR PARTS, EXPOSED TO OR DAMAGED BY FIRE! -
If not leaking, carefully light the appliance and use it according to the instructions in this manual. This appliance regulator and tank valve connection may contain two or more important safety features such as Excess Flow Control and High Temperature Activated Shutoff.
• FAILURE TO FOLLOW THESE INSTRUCTIONS MAY RESULT IN AN EXPLOSION OR FIRE THAT MAY CAUSE PROPERTY DAMAGE, SERIOUS INJURY, OR DEATH!
• NEVER LEAVE THIS APPLIANCE UNATTENDED WHILE IN USE! NOT TO BE USED BY CHILDREN!
Lighting the side burner
-
Open the side burner lid.
-
Ensure the control knob is in the “OFF” position.
-
Turn on the gas supply at the gas cylinder.
-
Push the control knob down and turn to the ignition position.
-
Hold the control knob in for at least 10 seconds to ensure the burner stays lit.
-
If the burner does not light after holding the dial in for 20 seconds, turn the control knob to the ‘OFF’ position and wait for 1 minute and try again. Do not continuously hold the control knob in as you may cause a build-up of gas.
-
In windy conditions shield from wind to ensure easy lighting.
-
Turn the control knob to alter burner settings as required.
Manual Lighting Instructions
- Place a lit match beside the burner (at the same location as the sparker shield).
- Push and turn the control knob to the high position.
Always protect your hands when handling anything near cooking surface of the side burner.
Turning off your side burner
Push the control knob in and turn to the “OFF” position. Turn the gas off and
disconnect the cylinder when not in use. The regulator must be disconnected
when the side burner is not in use.
FOOD SAFETY
Please read and follow this advice when cooking on your side burner:
-
Always wash your hands before and after handling uncooked meat and before eating.
-
Always keep raw meat away from cooked meat and other foods.
-
Before cooking, ensure side burner surfaces and tools are clean and free of old food residue.
-
Do not use the same utensils to handle cooked and uncooked foods.
-
Ensure all meat is cooked thoroughly before eating.
CAUTION – eating raw or undercooked meat can cause food poisoning (e.g bacteria strains such as E.coli) -
To reduce the risk of undercooked meat, cut it open to ensure it is cooked all the way through internally.
CAUTION – if meat has been cooked sufficiently the meat juices should be clear in color and there should be no traces of pink/red juice or meat coloring. -
After cooking on your side burner always clean the cooking surfaces and utensils.
CARE AND MAINTENANCE
-
Regularly clean your side burner between uses and especially after extended periods of storage.
-
Ensure the side burner and its components are sufficiently cool before cleaning.
-
Do not leave the unit exposed to outside weather conditions or stored in damp, moist areas.
-
Never douse the unit burner with water when its surfaces are hot.
-
Never handle hot parts with unprotected hands.
-
In order to extend the life and maintain the condition of your side burner, we strongly recommend that the unit is covered when left outside for any length of time, especially during the winter months.
IMPORTANT – We recommend that servicing of this side burner should be performed either after every 100 hours of use or annually, whichever is achieved soonest. -
Keep outdoor cooking areas with gas appliances clear and free from combustible materials, gasoline, and other flammable vapors and liquids.
-
Do not obstruct the flow of combustion and ventilation air.
-
Servicing shall be carried out only by authorized personnel. This appliance shall not be modified.
Burner (2) Maintenance
- In normal usage, burning off the residue after cooking will keep the burners clean.
- The burners should be cleaned annually, or whenever heavy build-up is found, to ensure that there are no signs of blockage (debris, insects) in either the burner portholes or the venturi tubes of the burners fitted over the valve outlets. A blocked burner can lead to a fire beneath the grill.
- Visually inspect the operation of the burners.
See the figure below showing the correct burning.
There should be flame from all portholes.
STORAGE
Do not leave your side burner uncovered when not in use. Store your side
burner in a cool dry place like a shed or garage when not in use to protect
against the effects of extreme weather conditions, particularly if you live
near coastal areas.
Prolonged exposure to sunlight, standing water, and sea air/saltwater can all
cause damage to your appliance.
(A cover may not be sufficient to protect your appliance in some of these
situations).
- Cover the burners with aluminum foil in order to prevent insects or other debris from collecting in burner holes.
- If the side burner is to be stored indoors, the gas cylinder must be disconnected and left outside. The gas cylinder should always be stored outside, in a dry, well-ventilated area, away from any sources of heat or ignition. Do not let children tamper with the cylinder.
- Cylinders must be stored out of the reach of children and must not be stored in a building, garage, or any other enclosed area.
Caution
If you smell gas – extinguish the burner. If the odor continues, immediately
contact your gas supplier.
In the event of an uncontrollable fire, immediately disconnect the gas
cylinder move it away from the fire, and contact the fire services. DO NOT PUT
YOURSELF AT RISK!
DO NOT SPRAY AEROSOLS IN THE VICINITY OF THIS APPLIANCE WHILE IT IS IN
OPERATION.
Ensure all packaging and plastic bags are disposed of safely.
DANGER
Do not put side burner in storage or travel mode immediately after use. Allow
the side burner to cool to the touch before moving or storing. Failure to do
so could result in fire resulting in property damage, personal injury, or
death.
TECHNICAL INFORMATION
This side burner is designed for outdoor use only using Universal LPG. Please
read all accompanying documentation carefully.
Model No: 60488922
ULPG at: 2.75kPA
Gas consumption: 10.5 MJ/h
Injector size-Side burner: 0.90mm
Countries intended for AU
| ****
---|---
GMK 10676
AS/NZS 5263.1.7
TROUBLESHOOTING
| PROBLEM | POSSIBLE CAUSE | SOLUTION |
|---|---|---|
| The burner will not light using the ignition system | LP gas cylinder is empty |
Replace with a full cylinder
Faulty regulator| Have the regulator checked or replace
Obstructions in burner| Clean burner
Obstructions in gas jets or gas hose| Clean jets and gas hose
Electrode wire is loose| Reconnect wire
Electrode or wire is damaged| Change electrode and wire
Low flame or flashback (fire in burner tube – a hissing or roaring noise may
be heard)| LP gas cylinder too small| Use larger cylinder
Obstructions in burner| Clean burner
Obstructions in gas jets or gas| Clean jets and gas hose
Windy conditions| Use BBQ in a more sheltered position
Gas valve knob difficult to turn| Gas valve jammed| Replace gas valve
HOW TO REACH US IF YOU NEED OUR SERVICE
Contact your local IKEA store. You will find the address and phone number in
the IKEA catalogue or at www.IKEA.com.
To ensure that we provide you with the best assistance, please read carefully
the Assembly Instructions and/or the User Instruction section of this manual
before contacting us.
This appliance shall only be used in an above ground open-air situation with
natural ventilation, without.
stagnant areas, where gas leakage and products of combustion are rapidly
dispersed by wind and natural convection.
Any enclosure in which the appliance is used shall comply with one of the
following:
An enclosure with walls on all sides, but at least one permanent opening at
ground level and no overhead cover. Within a partial enclosure that includes
an overhead cover and no more than two walls.
Within a partial enclosure that includes an overhead cover and more than two
walls, the following shall apply—
- at least 25% of the total wall area is completely open; and
- at least 30% of the remaining wall area is open and unrestricted.
In the case of balconies, at least 20% of the total of the side, back, and front wall areas shall be and remain open and unrestricted.
© Inter IKEA Systems B.V. 2020
Documents / Resources
| IKEA
594.003.98 GRILLSKÄR Kitchen Sink ut chrcl
BBQ
[pdf] Instruction Manual
594.003.98, GRILLSK R Kitchen Sink ut chrcl BBQ, 594.003.98 GRILLSK R Kitchen
Sink ut chrcl BBQ, Kitchen Sink ut chrcl BBQ
---|---
References
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>