DRIFT KKL-A08 Children Car with 2.4G Remote Control User Manual

USER MANUAL FOR CHILDREN BATTERY-OPERATED CAR
WITH 2.4G REMOTE CONTROL
MODEL : DRIFT
ITEM NO.:KKL-A08

KKL-A08 Children Car with 2.4G Remote Control

IMPORTANT! READ CAREFULLY AND KEEP FOR FUTURE REFERENCE!
THE USER MANUAL CONTAINS IMPORTANT INFORMATION ON THE ASSEMBLY, CORRECT USE AND MAINTENANCE OF THE PRODUCT. THE BO SUV COMPLIES WITH THE REQUIREMENTS OF EUROPEAN STANDARD EN 71-1-2-3.
WARNING! THE SHEMES AND FIGURES IN THIS INSTRUCTIONS ARE FOR ILLUSTRATIVE PURPOSE ONLY. THE PRODUCT YOU HAVE BOUGHT MAY DIFFER FROM THEM.
PARTS DIAGRAM ASSEMBLY STEPS, USE AND CHARGING

DESCRIPTION OF THE PRODUCT

Maximum up to10 meters

WARNING!

• DO NOT USE IN MUDDY TERRAINS!!!!!
•  ADULT ASSEMBLY REQUIRED. The product contains small parts, which are for adult assembly only.

Keep children away when assembling.

• Always remove protective material and poly bags and dispose before assembly.
• CHOKING HAZARD – Small parts. Not suitable for children under 36 months.

WARNINGS AND RECOMMENDATIONS FOR SAFE USE

• Warning! To be used under the direct supervision of an adult.
• NEVER LEAVE THE CHILD WITHOUT ADULT SUPERVISION. Always monitor the child while it is using the battery-operated car.
• Warning! This toy is unsuitable for children under 3 years due to its maximum speed.
• This toy has no breaks.
• Intended for children from 3 to 7 years of age with maximumweight up to 30 kg.
• Use only as intended. The battery-operated car is a toy – it is not intended to transport people on long distances or luggage and etc.
• Adult assembly required.
• Children under 3 years of age are not to be present during assembly of the car. Small parts. Risk of choking.
• Keep the packing away from children during the unpacking and afterwards.
• The assembly and charging of the batteries must be made by an adult.
• Use with caution. Skill is required to avoid falls or collisions causing injury to the user or third parties.
• Warning! Protective equipment should be worn. Not to be used in traffic.
• The product is intended for use only by one child at a session.
• Never use on roads, close to cars, on or close to steep hills or stairs, pools, or other water bodies, muddy terrains or swampy areas.
• Check regularly the condition of each part, since there is a risk of injuring your child in case of damage.
• Do not use the CAR if you find loosen, worn-out or damaged parts. The wheels must be moving freely.
• One must always use shoes during use. The child must not be barefoot during use of the toy or with shoes with slippery soles.
• One must always sit on the seat. Do not allow the child to step on the seat or to use the battery-operated car, while standing up.
• Your child must not jump with the car from curbs or other higher parts or bump into them.
• You must teach your child and the other children, which are near the car, not to touch its wheels with hands or other objects, while the car is moving.
• Do not tie or attach objects or accessories to the toy. This may lead to hanging, twining and disturbance of the balance causing injuring your child.
• Do not modify any of the parts of the product!
• Keep away from direct heat sources – heathers, open fires or others.
• Do not use the car in rainy days, do not get it wet with water or other liquids during play or during cleaning. This will prevent the risk of damage of the toy due to rust on the metal parts or disturbing the stability of the connections.

Rules for safe driving

• The children must be in Safe Zones for driving:
• Not to be used on slopes or steep areas or stairs, near swimming pools or other water bodies.
• Use the toy on even ground and in safe areas only. Such as– in your home, park or playground.
• Using the product behind vehicles, near or on high traffic, streets, rivers, slopes, escalators or other dangerous places is strictly forbidden.
• Never use on lawns or other grass areas, on or near steep slopes.
• Avoid sandy or other hard and rough surfaces. Do not use in poor weather (snow, rain, strong wind), or at places that are poorly lit, or places with poor visibility or with obstacles.
• Never use in the dark.Your child may encounter unexpected obstacles resulting in an accident. Use only during the day or at places that are well lit.
• It is forbidden to shorten the terminals of the electric cables or to add other electric parts.
• Periodically check the wires, bushings and connectors.
• Do not allow children to touch the wheels or be close to them, when the battery-operated car is in motion.
• The product has adjustable safety belts. Instruct the children to fasten their seat belts before use in order to guarantee their safety.
• Some accessories of the car may get damaged during improper driving, be careful.
• DO not use suddenly the forwards/backwards switch, while the car is in motion. It can be used only while the toy is stopped in place.
• When restarting the motor there may be some sparks. It is forbidden to start the car in highly flammable and explosive environments such as petrol stations.
• An adult must read this instruction carefully and give correct guidelines to children before playing with this product. Show them how to start and release the pedal, how to stop the car and how to act in case of malfunctions.
• When you stop using the toy, turn off the power.
• Do not change anything in the body and parts of the product. This may lead to destabilization of the toy and injury to your child.
• The following must be confirmedbefore using the product:
• Important! Before use of the product for the first time, the battery must be charged around 8 – 12 hours, but no more than that. Only an adult can charge and recharge the battery.
• Check regularly all screws, nuts and safety coverings and tighten them if necessary!
• Before each use check the seat. Whether it is correctly placed and mounted (installed) with the help of a screw.
• In order to avoid incidents, make sure that the battery-operated car is entirely safe before use.

IMPORTANT SAFETY INSTRUCTIONS

Battery/ Charger/ Alkaline batteries

1. The battery/ charger/ alkaline batteries are not toys and it is strictly forbidden for children to play with them.
2. Non-rechargeable batteries must not be recharged, do not recharge them.
3. Do not mix old and new batteries or batteries of different types: alkaline, standard (carbon-zinc) or rechargeable (nickel-cadmium).
4. Only an adult must charge the batteries.
5. Remove the rechargeable batteries from the product before you start charging them.
6. Observe the correct polarity ± indicated at the battery compartment.
7. The discharged batteries must immediately be removed from the product.
8. Remove the batteries if you are not going to use the product for a long time.
9. Do not shorten the battery terminals.
10. Use only the rechargeable battery and charged provided by the manufacturer.
11. Do not use the battery or charger for other product, because this may lead to overheating, fire or explosion.
12. DO NOT OPEN the battery or charger.
13. DO NOT CHARGE the battery backwards.
    Always keep the battery dry. The battery must not get in contact with fresh or salt water.

Charging of the rechargeable battery

1. Before use for the first time you must charge the rechargeable battery for 8 – 10 hours, but no more than that. The battery must be charged by an adult only. Never allow a child to charge the battery.
2. Before plugging the adaptor for charging of the battery, you must turn off the power button.
3. When the normal speed of the car starts to significantly decline or after each use of the product, charge the battery for 8 – 10 hours, but never more than 12 hours.
4. Check the battery, charger and their connectors and cables for extensive wearing or damage every time before you start charging the battery. If you find any wearing or damage, do not use the charger or battery until the worn or damaged part is replaced.
5. The battery must be charged in dry areas only.
6. It is normal for the battery and charger to become warm during charging.
7. Charge the battery at least once a month, even if the motor has not been used.
8. At room temperature under 5 degrees Celsius, the charging must take 3-5 hours more. Please, do not use this product under – 5 degrees Celsius.

PARTS LIST
Before you start to assemble the battery-operated CAR, take the parts out of the packaging and check whether all parts indicated in the list below are present. Keep the packaging until you have completely finished. See Figure PD: Body car 1pc,. Seat 1 pc., Rear wheel 2 pc,. Front wheel 2pc,. Steering wheel 1pc,. Front window 1pc., Rear wing 1pcs , rear view mirror 2 pc ,. Seat 1 pc, wheel covers 4 pc , Remonte control 1pc.,Charge 1pc.

ASSEMBLY STEPS

1. Remove the body car and press on front wheel insert the gasket
2. Rear wheels’ installation . Remove the nuts and washers from the rear axle. Attach to the left and right side of the rear axle: rear wheel → washer → nut. The cogwheels of the wheels must fit tightly to the cogwheels of the gearboxes. Using a spanner tighten both of the nuts on each side of the rear axle. Then attach the covers to the wheels. Push them carefully to fix them. You will hear a click.
3. Use point 2/3/4/5 and 6 for the remaining wheels . 7.Buckle the wheel cover, 8.Connect the power cord to the steering wheel,9.insert the steering wheel into the front of the car.tighten the screws. 10/11.Connecting the battery Connect the red cable to the red terminal of the battery. Follow the correct polarity. Never connect black cable to red terminal or vice versa. This may lead to short circuit. Turn on the power of the car to check if the connection was successful. Attaching the seat Remove the 2 screws
   from the place to which the seat must be attached. Place the seat at the rear part of the car. The plastic pins of the rear part of the seat must be fixed into the corresponding openings in the car body. Re-attach the 2 screws and fix them using a screwdriver.
   12. Attaching the front windshield Attach the windshield to the front part of the car’s body. Insert its plastic pins into the corresponding openings of the body. Press carefully down to fix it. Warning! Do not press too hard as you may break some of the parts , .and insert the reflector into the car.
   13. Place the rear spoiler and you are ready to use the product.
   14.You have finished you can use the car.

USE OF THE BATTERY-OPERATED SUV

Notice:

1. When you change the direction of movement, first make sure that the SUV does not move. Otherwise, if you change suddenly the direction of movement without stopping the CAR, you may cause damage of the gears and motor.
2. If you are using the remote control, follow the guidelines in this manual.

Operation and Functions – See Figure U:

1. Music player – buttons for music, volume up and volume down.

2. Battery display – shows the left charge in the battery.

3. Dashboard

4. Power: Push the ON/ OFF button to start the car

5. Lights switch – Press to turn on or off the lights.

6. High-low speed switch: the CAR moves in high speed only in forward mode.

7. Button for movingForward/ Stop/ Backward:
   •Moving Forward: Put the Forward ▲ /Stop/ Back ▼ switch in position Forward ▲ and press the pedal in order to move the SUV forward.
   •Moving Backward: Put the Forward ▲ /Stop/ Back ▼ switch in position Back ▼ and press the pedal to move the CAR backwards.
   •Stop: Switch to Stop position or lift your leg from the pedal in order to stop the car frommoving.

8. USB jack – to connect flash driver or your phone.

9. TF slot – to insert SD card.

10. MP3 jack – to connect to MP3 Player.

Do not listen to loud music, because this may lead to impairment of the hearing

REMOTE CONTROL USE

ONLY AN ADULT CAN USE THE REMOTE CONTROL!
The use of the remote control is always with priority over the manual and pedal operation with the SUV. (If you use the remote control, the pedal will not work.)
I. PLACING OF THE BATTERIES:
WARNING! The placement of batteries should be performed in the absence of children!

1. The batteries are not included in the set.
2. Remove the screw of the lid of the battery compartment with a screwdriver and set it aside.
3. After that place 2 pcs AAA (LR03) batteries in the compartment, make sure that you observe the respective polarity (+/-) when you place them, it is indicated on the bottom of the compartment.
4. Replace the cover of the battery compartment and secure it with the screw.
5. The batteries must be handled by an adult. Do not allow the children to play with the batteries.
6. Warning! The placing of the further change of the batteries must be done by an adult.

II. Buttons of the remote control – See Figure RC:

• F – Forward – press in order to move the CAR forward;
• B – Backward – press in order to move the CAR backward;
• P – Stop/ Pause– press to stop the CAR frommoving;
• L – Turn on the left– press in order the CAR to turn on the left;
• R – Turn on the right – press in order the CAR o turn on the right;
• S – Speed select;
• IL– LED indicating light for the different speeds;

III. Connecting the remote control device to the CAR :

1. Hold the Forward and Backward buttons at the same time for 3 seconds. The first speed indicator will start flashing. Turn on the power of the SUV. The light indicator should change from flashing to long light. This means that the connection was successful.
2. If the connection wasn’t successful, turn off the power of the CAR and repeat step 1.
3. The RC will turn into power saving mode automatically if you do not use it for 10 seconds.
4. The remote control used to operate the battery – operated CAR is with item number M23042 Moni Trade Ltd., hereby, declares that this type of radio equipment model GB6675, complies with Directive 2014/53/EC. The complete text of EC declaration for compliance can be found at the following Internet address: www.moni.bg.

IV. IMPORTANT INFORMATIONABOUT THE BATTERIES:

1. Always remove the discharged batteries and do not throw them away with the household waste, use the places designated for that purpose. They are recyclable.
2. Use only batteries with the size and voltage, marked on the bottom of the battery compartment.
3. Alkaline batteries are recommended.
4.  Always remove the batteries, if you will not use the product for a long period of time.
5.  When you replace the batteries always replace them with new ones, always replace all batteries. Children should not be present while you are replacing the batteries.
6.  Do not mix old batteries with new ones.
7. Do not mix alkaline, standard (Carbon – Zinc), or rechargeable (Nickel – Cadmium) batteries.
8. Do not throw the batteries in fire, because they may blow up or leak.

CHARGING OF THE RECHARGEABLE BATTERY OF THE TOY
THE RECHARGEABLE BATTERY MUST BE CHARGED BY AN ADULT ONLY.
WARNING!

• IN ORDER TO AVOID FIRE AND ELECTRIC SHOCK:
  – Always use only the rechargeable battery and adapter provided with the bought product. NEVER USE battery or charger of ther brand or another product.
  – Do not place the battery or adapter for another product. This may result in overheating, fire or explosion.
  – NEVER change the electric current. Making any changes to it may lead to short circuit, fire or explosion or the system may permanently get damaged.
  – DO NOT ALLOW DIRECT CONTACT BETWEEN THE TERMINALS OF THE BATTERY. THIS MAY LEAD TO FIRE OR EXPLOSION.
  – Do not allow any liquid to get in contact with the battery or its components.
  -During the charging of the battery explosive gases, heat or flammable substances accumulate. Charge the battery in well ventilated places ONLY.
  Never pick up the battery by its cable or adapter. This may lead to damaging of the battery resulting in a fire. Pick the battery by the corpus ONLY.
  •Never pick up the battery by its cable or adapter. This may lead to damaging of the battery resulting in a fire. Pick the battery by the corpus ONLY.
  – Charge the battery in dry areas only.
  •The battery terminals, connectors and parts related to them contain lead and lead components, chemicals, which according to the state of California can cause cancers and reproductive disabilities. Always wash your hands after handling the battery.
  • Do not open the battery. The battery contains lead acid and other materials, which are toxic and corrosive.
  • Do not open the adapter! The exposed wires and electric components in the corpus of the adapter may cause electric shock.
  • Only an adult can handle and charge the battery. NEVER allow children to work with or charge the battery. The battery is heavy and contains lead acid (electrolyte).
  • Never drop the battery. This may lead to permanent damage of the battery or serious injuries.
  • Before you start charging the product you must check whether the adapter, battery and cables are in good working order. If there is damage on any of these parts, you must stop using them, until the damage is removed.
  • Do not let the battery discharge entirely. You must recharge it after each use or once a month if you are not going to use it regularly.
  • Do no turn the battery backwards.
  • Always secure and fasten the rechargeable battery with the bracket. Otherwise the battery can fall and injure the child, if the battery-operated CAR upturns.
  • It is normal for the adapter to get heated during charging, but if the adapter gets very hot, you must stop the charging and check the adapter and battery.
  •The charging socket is situated under the seat of the CAR.
  • Before you put the battery-operated CAR in storage, you must charge its battery completely. After that every 3 months you must charge it, in order to prolong its life.
  • During charging the CAR is not usable, because the current of the electric system is stopped.
  •Switch the POWER BUTTON OFF before staring to charge the battery.
  •Before use for the first time, you must charge the battery for at least 8 – 10 hours. Do not charge the battery for more than that to avoid overheating the battery and the charge.
  •When the batter- operated CAR starts moving more slowly, you must recharge the battery.
  •After each use or at least once a month you must recharge the rechargeable battery between 8 and 10 hours, but not more than 12 hours.
  •Children are not allowed to handle the adapter. Only an adult must handle it. After charging you must always store it at a place out of the reach of children. The adapter is not a toy.

1. Switch the battery-operated CAR off before you start charging the battery.
2. See Figure CH. Plug the bushing of the adapter in the charging socket..
3. Insert the plug of the adapter in a socket of the main electric grid.
4. Make sure that the battery-operated CAR is turned off.

REMOVAL OF THE DISCHARGED BATTERY
Your battery at one point will lose its ability to hold charge. Depending on the amount of use and varying conditions, the battery should be used between one and three years. In order to replace the battery and remove the discharged one, follow the steps below:

1. Remove the seat of the battery-operated car.

2. Remove the jacks of the battery’s cables.

3. Remove the metal bracket that protects the battery from falling.

4. Carefully lift the battery.
   • Depending on the state of the battery (for example leakage) you may have to wear protective gloves before you remove the battery.
   • Do not lift the battery by its terminals or cables.

5. Place the discharged battery in a plastic packaging.
   Important! The sealed lead-acid battery must be recycled or thrown away in an ecologically friendly manner for the purpose of avoiding pollution of the environment. The battery contains lead acid (electrolyte) and must be discarded in an ecologically friendly manner in accordance with the regulatory requirements. DO NOT throw the rechargeable battery in fire, because it may explode or leak. DO NOT throw the lead-acid battery in the containers for household waste. The incineration (burning), land filling or mixing of the sealed lead-acid batteries with the household waste is forbidden by law. The discharged rechargeable battery can be given at the local recycling center for recycling or at a center for sale of such batteries.

6. Replace the battery with new one and reconnect all cables and terminals.

7. Place the metal bracket protecting the battery from upturning or falling back on.

8. Return the seat of the battery-operated SUV back in place.

TROUBLESHOOTING GUIDE

When the car is overloaded or due to improper use, the fuse will switch off automatically.| If this happens, wait for several minutes without using the product. The fuse will switch on automatically.
You haven’t press the power button correctly.| Use the car correctly according to how it is described in this manual.
The battery cable has fallen off.| Re-connect.
The battery is damaged.| Change with new. For this purpose contact store you bought the product from.
The cables of the electric circuit are broken or damaged.| For repairs, contact the store you bought the product from.
The driving motor is damaged.| The car must be examined and repaired by a professional. Contact the store you bought the product from.
The battery does not charge| The battery cable’s plugs are loose.| Check whether the battery cable’s plug is firmly
connected. Re-connect.
The charger is not plugged in.| Check if the charger is plugged in to a working socket of the main electric system.
The charger is damaged.| Contact the shop you bought the product from.
The battery-operated car cannot operate for
a long time.| The time for charging the battery is shorten.| Charge the battery for the recommended time and not shorter, or charge every time after each use. The charging must be done at least once a week. Charge for 8 —12 hours, but not more than 18 hours.
The battery is old and cannot hold charge anymore.| Usually the battery, when being charged regularly, can last from 1 to 3 years. If the battery cannot hold any more charge, replace it with a new one. Contact the shop you bought the product from.
During charging the charger is warm and
there is buzzing sound from it.| This is due to a chemical reaction.| You should not be worried as this is a normal chemical process.
Problem| Possible reason| Solution
---|---|---
The battery-operated car moves slowly.| The batteryoes not have enough charge.| Recharge the battery regularly after each use. It is recommended to charge it from 8 till 10 hours but not more than that.
The battery is old and cannot hold charge anymore.| Usually the battery, when being charged regularly, can last from 1 to 3 years. If the battery cannot hold any more charge, replace it with a new one. Contact the shop you bought the product from.
The battery -operated car overloaded| Reduce the load of the battery-operated car. The
maximum weight of the child using the battery-operated car must be not more than 30 kg.
The battery-operated car is used on uneven ground — sand/ gravel/ grassy area.| Use only on even asphalt surface!

CLEANING AND MAINTENANCE OF THE PRODUCT

Cleaning:

1. Do not clean the product with a hose. Do not wash it with water and soap. Do not use the car, when it rains or snows. Water may damage the motor, electric system or battery.
2. Clean the battery-operated car with soft, dry cloth only. In order to restore the shine of the plastic parts, use polishing agent for furniture WITHOUT wax. Do not use strong abrasive cleaning agents.

Maintenance and storage:

1. The responsibility to check the main parts of the toy before use is entirely to the parents/ adult. Regularly check for potential risk of damage / injury – the battery, adapter, electric cables or wires, bushings, screws, body, moving systems, wheels, fastening components – whether they are in good working condition or not, whether there is any damage, broken or chipped parts. If you find any, you must stop using the product, until the damage is removed. Contact the shop you bought the product from or the importer.
2. Make sure that the plastic parts of the toy are not cracked or broken.
3. From time to time use lubricating oil, in order to oil the moving parts such as wheels and moving connections. You must apply a very thin layer of the oil and be careful while applying it.
4. Store the car in upright position only, do not turn it upside down and do not tilt it. Park the battery-operated car indoors or cover it with sailcloth, in order to protect it in humid weather.
5. When you are not going to use the product, you must store it at a dry, cool and well ventilated place. Do not store the product close to sources of heat – open fire, heating devices or cookers and also at humid places.
6. FOR ADULTS ONLY: recharge the battery after each use. Recharge the battery at least once a month, when you are not using the battery-operated car.
7. When the battery-operated car is not being used, all electric sources must be switched off. All switches must be in zero position or in “stop” position. Disconnect the bushings of the battery’s cables.
8. If you are not going to use the product for a long time, you must charge the battery completely, before you put it for storage. You must charge the battery every three months in order to prolong its life.
9. Before you put the car for storage you must switch the power button OFF, remove the cables from all bushings and the rechargeable battery of the car. Store it at a suitable place (dry, cool and well ventilated place). Do not allow children to play close to the battery.
10. IMPORTANT! DO NOT MAKE ANY CHANGES OF THE BODY OF THE car AND ITS MAIN PARTS AND ALSO THE ELECTRIC INSTALLATION! This may lead to damaging of the car, improper operation and a risk of injury to the child. These parts must be maintained by an expert – authorized repair shop or importer.
11. Do not charge non-rechargeable batteries, do not mix old and new or different types of batteries. Observe the correct polarity while placing the batteries.
12. .Do not change the structure of this product and its electric system. Any changes must be performed under the guidance of a technician only. In case of a problem contact the shop you bought the product from or the importer.

The battery-operated Named DRIFT is produced by Moni Trade Ltd.
Importer: Moni Trade Ltd.
Address: Bulgaria, city of Sofia, Trebich quarter, 1 Dolo str.
Tel.: +359 2/ 936 07 90; Web: www.moni.bg

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>