SUNEFUN 2kg kitchen composter with biological digestant (Enzyme) User Guide
- June 6, 2024
- SUNEFUN
Table of Contents
New model of kitchen composter with biological digestant (Enzyme)
2 Model 2kg
User’s Guide
Please read this manual before use to ensure use it correctly and safely.
Digestants (Microorganisms) are alive beings, so you must read the
instructions carefully before use.
Biological digestant is harmless to the body. Visit us online:
www.sunefun.com
OnePrepare before use
Installation precautions
- Please put the composter in the room (kitchen) or shade shelter, well-ventilated terrace or other analogous places.
- Placed in the level surface. 10cm
- Keep away from walls more than 10cm distance.
- Keep away from water.
- There is an air outlet in the lower part of the product. Please do not block it when placed. Please do not place on plastic foam or carton.
- Placed outside of the door may cause low-temperature failure in winter. So please keep warm or insulated from the wind.
Preparations before start.
- Open the cover, put the digestant.
- 400ml Add about 400ml of water.
- 50/60Hz 220V Please plug the power cord into the socket, access power (50 / 60Hz single-phase 220V).
- Put down the cover, power on, check if it works: Indicator Description
a — Bluish grey flashing light – normal work.
b — Green flashing light – dehumidification state, this state prohibits putting more garbage.
c — Red flashing light – Photocatalyst alarm.
d — Blue flashing light – motor alarm.
e — Purple flashing light – fan alarm.
f — 45 4 Golden flashing light – temperature abnormal alarm means the temperature is less than 45 degrees for continuous 4 hours.
g– Control panel light: deodorization (electric heating system start) state, off that means “off deodorization”.
Precautions before use
- Biological digestants in the first use need to be warmed up after 6 hours to achieve the best working condition, allow the new machine to operate 6 hours before the organic waste can be added (according to different biological digestant set). 1 1.5-2.0kg
- Do not overfill organic waste at once. The recommended amount is 1.5-2.0kg of waste per day.
- Please try to remove the excess water of the organic waste before putting into the chamber, will improve the treatment efficiency.
Storage method
Do not need to be unplugged when it is not in use. After 30 hours it will
automatically enter power-saving mode. After 100 hours it will automatically
shut down.
If you do not use it for a long time, please place it in a well-ventilated,
dry place, unplug the power, clean the internal exhaust net, cover, etc.
TwoInstructions for use
Method of putting raw garbage
- Please cut fibrous raw garbage, especially watermelon rind, fruit peel, cabbage leaves, raw vegetables, leather into pieces smaller than 1 – 2cm.
- For best results to wash and remove excessive salts and oils for the organic waste.
- Remove the excess water from the humid raw garbage.
- Please do not put too much time like vinegar, soy sauce, salt, mono-sodium, etc.
The substance can not be added
Do not put ingredients such as bones, pig bones, cigarettes, shellfish, medicine, chopsticks, toothpicks, plastic bags, plastic, metal, paper, cloth, glass, etc. (This model is for home use only).
Functional Principle Chart
- The negative pressure sucks fresh air into the working chamber, increasing the vitality of biological digestant efficiency;
- The water and gas are created by a reaction between microbe (enzyme) and kitchen rubbish in the chamber, before being exposed to the ultraviolet system. UV CO2
Process in the ultraviolet system
- The ultraviolet system produces the ozone after the gas and water go into it.
- The ozone decomposes the organic gas and creates water and CO2.
- The catalyst in the first chamber is used to break down the foul smells.
The catalyst in the second chamber absorbs the remaining stink and ozone.
Finally the fan exhaust is clean, fresh air.
Operation description
Panel description
- Power supply
- Powered on “bluish-grey” light as normal work, turn off the power the flashing light does not shine.
- Dehumidification, Deodorization
- When the moisture level exceeds the limit, the dehumidification process begins, the green light will flash. At this time do not add any additional waste until the light has closed back to bluish-grey.
- The smell comes out, you can use the deodorant function button, can be eliminated immediately.
Operating instructions
- Add the biological digestant then plug the power, running 4 hours at the first time (depending on a different kind of digestant). 1.5-2.0 /
- Open the cover and put the correct amount of organic waste into the composter (1.5-2.0 kg/day).
- Close the cover, the stirring shaft will begin to run, the biological digestant will begin to decompose the organic waste.
- During normal operation, the barrel is heated to maintain the best state of digestant’s temperature.
- After 24 hours working, most of the waste is removed, the odor and water vapor are exhausted through the deodorizing device.
- When the odors are noticed, press the deodorant key, after 15 minutes it will automatically resume to normal operation.
Safety and protection
- Please do not disassemble or modify this product without technical guidance.
- Please do not place it in the place where the rain can touch or beside the sink.
- Do not touch the power supply with wet hands.
- Please do not let the children climb the composter or get into the composter.
- Please pay attention to the safety of the power cord.
- Please do not let the children contact with the digestant.
- Do not clean this product with gasoline, rosin and other flammable substances.
- Please do not put bowls, chopsticks and other hard objects into the mixing barrel.
- Please safely use the power, set the appropriate power supply and protection.
- Unplug the power when cleaning the product.
Care and Maintenance
Commodity cleaning
Clean the inside of the mixing barrel once a week, remove the cover, clean the foreign or sticking object to the inner wall with a brush, including the exhaust filter.
The common problems and treatments:
The food waste put in is so wet that some water can be seen at the bottom of the barrel.
a. Treatment: Hold on putting more wet food waste in till water can not be
seen; Also, more wood dust or caving can be added to absorb water.
b.The decomposition efficiency seems to be reduced.
Treatment: Add new digestant when the old had been used too long; much too wet
in the barrel should be lowered; Review whether bactericidal substances have
been put in (such as alcohol, detergent, excessive grease or salt)
c. Mixture in the barrel is so dry that it smokes when the lid is opened.
Treatment: Put some clean water or high moisture food waste. Tap water should
be dried for ten minutes before adding.
By-product removal and storage:
a. This product is a machine that uses biological digestants to treat waste.
Byproducts can be treated as general waste and also can be used as good
fertilizer and so on.
b. When fertilizing flowers or vegetables with the byproducts, please keep it
at least 10 cm from the plants, better digging hole for it or mixing some
soil, in case of burning the plants with excessive fertilization.
Please do not hesitate to drop us an email if you have any concerns or questions.
Soochow Sunefun Electronic Co., Ltd
NO.900 Zhujiang Rd.,SND,Suzhou,Jiangsu.China
Cellphone：0086-189-9442-0557
Fixed phone：0086-512-6544-0557
Email：sunefunjackie@hotmail.com