RADIO FLYER 997 DJ Dance and Spin with Remote Control Instruction Manual

RADIO FLYER 997 DJ Dance and Spin with Remote Control Instruction Manual

WARNING

ADULT ASSEMBLY REQUIRED.

Choking hazard to children under the age of 3 years – contains small parts prior to assembly. All fasteners should be fully tightened.

Children should not handle parts, including the battery and electrical components, or help with assembling the vehicle.

Please keep instructions for future reference.

Tools Required

Removing Seat

Connect battery

Lock

BATTERY CHARGING

6V battery must be fully charged before use.

• Red Light: Charging – Do not ride.
• Green Light: Fully Charged – Ready to ride.
• Never charge the battery longer than 18 hours.

1. Only use the provided Radio Flyer 6 volt charger to charge the 6 volt battery. Power source or wall outlet must be 120V 50/60Hz. If the wall outlet is controlled by an on/off switch ensure that the switch is on.
2. Charge the battery after every use.
3. Never charge the battery longer than 18 hours. Failure to follow these instructions may damage your battery and will void your warranty.
4. Once the battery is completely charged, disconnect the charger from the wall outlet and remove the charger plug from the car.
5. The battery does not need to be removed from the vehicle. Keep the battery in the rear compartment when charging.
6. Before charging the battery, examine the battery case for cracks and other damage which may cause sulfuric acid to leak. If damage is detected, please contact Radio Flyer Customer Service immediately and do not use the product any further.

Volume Adjustment

Volume level can be changed at any time by removing the seat, adjusting the volume slide switch, and then replacing the seat.

• High volume

• Low volume.

• Off

TROUBLESHOOTING:

PROBLEM: Vehicle runs but sounds are not working:

• Volume Setting: Confirm the volume slide switch is not set to “Off”. Set slide switch to low or high volume to hear music.
• Check all wires and connectors. Make sure that they are connected properly. See assembly step 6.

Switching between speed modes.

Steering wheel function:

Parent Remote Control Operations:

CAUTION: TO AVOID BATTERY LEAKAGE

• DO NOT incinerate used batteries.
• DO NOT dispose of batteries in fire.
• DO NOT mix old and new batteries or types of batteries.
• DO NOT use rechargeable batteries.
• DO NOT recharge non-rechargeable batteries.
• DO NOT short-circuit the supply terminals.
• Different types of batteries should not be mixed.
• Only batteries of the same or equivalent type as recommended are to be used.
• Exhausted batteries should be removed from the toy.
• Dispose of batteries safely.
• Batteries to be inserted with the correct polarity

Remote control LED (Light Emitting Diode) indicator tables:

Pairing

ATTENTION: Confirm that parent remote control is paired to vehicle:

If car does NOT move forward, your parent remote control is NOT paired to your vehicle. Continue to Step 16.

To pair parent remote control to vehicle:

1. Begin with car in the off position

: OFF

2. Press and hold the “Backward” button and “Emergency Stop” button at the same time. The blue LED on the front of the parent remote control will blink.
   

3. While the blue light on the remote control is blinking, turn the car on.

: ON

4. The blue light on the remote control will stop flashing when the pairing is complete. To test if pairing is complete, follow step 13.
   

To preserve battery life

Turn off both the car and remote after each use.

ON/OFF Switch LED (Light Emitting Diode) Indicator Table:

WARNING: TO AVOID SERIOUS INJURY:

• Users should always remain seated while using this product.
• Adult supervision is required.
• Always wear shoes.
• Never use in roadways, near motor vehicles, on or near steep inclines or steps, swimming pools or other bodies of water.
• Never ride at night.
• Ride only on smooth, level ground.
• Keep both hands on steering wheel and keep both feet on footrests.
• Keep away from fire.
• Use only original parts, battery and charger. Never use unauthorized substitute parts. Use of unauthorized parts may damage your vehicle, void your warranty and even result in risk of injury.
• Never allow more than 1 rider.
• Maximum weight 43.0 lbs (19.5 kg).
• RISK OF FIRE: Do not bypass. Replace only with the Radio Flyer charger and battery provided for this product.

BATTERY WARNINGS

DANGER:

To prevent electric shock, do not immerse in water; wipe clean with a damp cloth.

WARNING:

TO PREVENT FIRE, EXPLOSIONS OR SERIOUS INJURY

• Read the safety instructions on the battery.
• Examine the battery, charger, and all connections for excessive wear or damage before each use. Do not use if damage or wear is found. Replace immediately.
• Always secure the battery using the battery retainer.
• Only carry the battery by holding onto the main casing.
• Never modify the electrical system.
• Use only Radio Flyer battery and charger specifically meant for this product.
• Do not use Radio Flyer components in other battery operated vehicles/toys.
• Do not touch motor after prolonged periods of use. Motor housing may be hot. Handle carefully.
• This battery can expose you to chemicals including lead, which is known to the State of California to cause cancer and birth defects or other reproductive harm. For more information go to: www.P65Warnings.ca.gov

DANGER/POISON:

• The battery contains corrosive acid that can cause blindness or burns. Contact physician immediately if exposed.
• Keep out of reach of children.
• Do not open battery

CAUTION:

Use the charger in dry locations only.

VEHICLE CARE

MAINTENANCE INSTRUCTIONS:

1. It is the responsibility of the adult who assembles this product to properly install all parts included in the carton. These instructions are valuable.
2. Check nuts and bolts often and tighten if necessary.
3. Any parts showing evidence of wear should be replaced immediately.
4. Check all screws and their protective coverings regularly and tighten as required. Check plastic parts on a regular basis for cracks or broken pieces.
5. During snowy or rainy weather, the vehicle should be stored inside.
6. Do not operate the vehicle in wet or snowy conditions.
7. Do not clean the vehicle by spraying with a hose. Water or moisture in the motors, battery, or electrical components can cause component failure.
8. A non-wax furniture polish can be used to clean plastic parts. Do not spray the vehicle with a hose or submerge in water.

FCC Statement (United States Only)

This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to Part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference in a residential installation. This equipment generates uses and can radiate radio frequency energy and, if not installed and used in accordance with the instructions, may cause harmful interference to radio communications. However, there is no guarantee that interference will not occur in a particular installation. If this equipment does cause harmful interference to radio or television reception, which can be determined by turning the equipment off and on, the user is encouraged to try to correct the interference by one or more of the following measures:

• Reorient or relocate the receiving antenna.
• Increase the separation between the equipment and receiver.
• Connect the equipment into an outlet on a circuit different from that to which the receiver is connected.
• Consult the dealer or an experienced radio/TV technician for help.

Note: Changes or modifications not expressly approved by the manufacturer responsible for compliance could void the user’s authority to operate the equipment. This device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) this device may not cause harmful interference and (2) this device must accept any interference received, including interference that may cause undesired operation.

CAN ICES-3(B)/NMB-3(B)

This device contains licence-exempt transmitter(s)/receiver(s) that comply with Innovation, Science and Economic Development Canada’s licence-exempt RSS(s). Operation is subject to the following two conditions:

1. This device may not cause interference.
2. This device must accept any interference, including interference that may cause undesired operation of the device.

This equipment complies with IC RSS-102 radiation exposure limits set forth for an uncontrolled environment.

GUIDELINES FOR SAFE DRIVING:

1. Before children use this vehicle, an adult should carefully evaluate the driving area as well as the child’s ability to drive the vehicle safely. Teach appropriate safety rules to your child before allowing operation of this vehicle. These rules should also be reviewed with other children who want to drive the vehicle.

2. Avoid contact with moving/rotating parts, such as the motor, gear box, and wheels.
   Contact with these parts can cause serious injury.

3. Do not operate the vehicle when it’s positioned on its side or upside-down.

4. Do not operate the vehicle near flammable vapors (gasoline, paint thinner, acetone, liquid wax, etc.) as the electrical switch emits an internal spark, which could cause an explosion or fire.

5. To prevent unsupervised use of the vehicle, disconnect the battery when the vehicle is not in use. See assembly step 5.

6. Never allow the vehicle to be used if the seat is not connected properly.

Please read this instruction manual before assembling the product.

All assembly should be completed by an adult. If any parts are missing or damaged please contact Radio Flyer Customer Service at 1-800-621-7613 or visit RadioFlyer.com

BATTERY CARE:

• The battery must be handled by adults only.
  The battery is heavy and contains sulfuric acid.

• If the battery begins to leak, avoid contact with the leaking acid and place the battery in a plastic bag. If acid comes in contact with skin, eyes, or is internally ingested contact a physician immediately. See section titled “Battery Disposal” for proper disposal instructions.

• Never allow the battery to discharge completely. Battery should be charged before it is completely drained.

• Charge the battery before storing the vehicle.

• Fully charge the battery at least once per month, even if the product hasn’t been used. Leaving the battery in a discharged state can shorten the life of the battery.

• Charge the battery after each use, regardless of how long the vehicle was used.

• Store the battery in temperatures between 35 °F (1.7 °C) and 77 °F (25.0 °C) for optimal performance.

• Never charge the battery longer than 18 hours. Failure to follow these instructions may damage your battery and will void your warranty.

BATTERY DISPOSAL:

1. Recycle or dispose of non-spillable sealed lead-acid battery in an environmentally sound manner.
2. Do not dispose of your lead-acid battery in a fire. The battery may explode or leak.
3. Do not dispose of your lead-acid battery in your regular household trash. The incineration, landfilling, or mixing of sealed lead-acid batteries with household trash is prohibited by law in most areas.
4. Return an exhausted battery to a federal or state approved lead-acid battery recycler, such as a local seller of automotive batteries. Contact your local waste management officials for other information regarding the environmentally sound collection, recycling and disposal of lead-acid batteries. If you live in the State of Florida or the State of Minnesota, it is prohibited by law for anyone to throw away lead-acid batteries in the municipal waste stream

6V battery must be fully charged before use.

TROUBLESHOOTING

IMPORTANT! If you experience a problem with your vehicle, first check the Problems and Solutions Guide below. If you still experience a problem, please contact Radio Flyer Customer Service, toll-free at 1-800-621-7613 or visit radioflyer.com for additional helpful hints.

vehicle power switch located on the back of the vehicle is “ON.”
Parent Remote Control Out of Range| Bring parent remote control within 60.0 feet (18.3 m) of vehicle. If you are within 60.0 feet (18.3 m) of vehicle and vehicle is not responding, replace remote control batteries.
Undercharged Battery| Charge the battery. Battery should be charged before first use. Never charge the battery longer than 18 hours. Check battery connections during charging. Check all wires and connectors. Make sure that they are connected properly. See assembly step 5. Make sure wall outlet power is “ON.”
Loose Wire/Connector| Check all wires and connectors. Make sure that they are connected properly. See assembly step 5.
Tripped Thermal Fuse/Switch| Thermal switch may have tripped because the vehicle was overloaded or the driving conditions were too severe. Once the switch/fuse has tripped, release the button on the steering wheel and wait 15 seconds before operating the vehicle again. To avoid tripping the fuse, do not overload the vehicle by exceeding the 43.0 lb (19.5 kg) maximum weight capacity. Do not pull anything behind the vehicle or drive up hills as it will trip the fuse. Do not run into fixed objects, which can cause the wheels to stop spinning and ultimately trip the fuse.
Old Battery| Improper care and charging may lead to a shorter battery life. Please contact Radio Flyer customer service for replacement parts.
Electrical Switch Damage| The electrical switch may have become corroded due to water or moisture. Contact Radio Flyer Customer Service and provide pictures of damaged components.
Defective Motor| Call Radio Flyer Customer Service for additional support.
Short Run Time (Less than 35 Minutes)| Not Powering Vehicle OFF after Each Use| Turn vehicle power switch ”ON” before each use, and turn power switch “OFF” after each use
Undercharged Battery| Charge the battery. Battery should be charged before first use. Never charge the battery longer than 18 hours. Check battery connections during charging. Check all wires and connectors. Make sure that they are connected properly. See assembly step 5. Make sure wall outlet power is “ON.”
Overcharged Battery| The battery should not be charged for more than 18 hours. Charging for periods greater than 18 hours can cause damage to the battery life.
Old Battery| Improper care and charging may lead to a shorter battery life. Please contact Radio Flyer customer service for replacement parts.
Vehicle is Running Slow| Vehicle is Overloaded| Maximum weight capacity = 43.0 lb (19.5 kg). Overloading the vehicle will cause lower speeds.
 | Driving Conditions are Too Severe| Driving on hard level ground is preferred. Driving on an incline will decrease the speed of the vehicle
 | Undercharged Battery| Charge the battery. Battery should be charged before first use. Never charge the battery longer than 18 hours. Check battery connections during charging. Check all wires and connectors. Make sure that they are connected properly. See assembly step 5. Make sure wall outlet power is “ON.”
 | Old Battery| Improper care and charging may lead to a shorter battery life. Please contact Radio Flyer customer service for replacement parts.
 | Speed Select Switch is Set to Speed 1| Select Speed 2. See assembly step 10.
Vehicle Won’t Run When the Steering Wheel Button is Depressed| Vehicle is Not Turned ON| Make sure vehicle power switch located on the back of the vehicle is “ON.”
Loose Wire/Connector| Check all wires and connectors. Make sure that they are connected properly. See assembly step 5.
Electrical Switch Damage| The electrical switch may have become corroded due to water or moisture. Contact Radio Flyer Customer Service and provide pictures of damaged components.
Defective Motor| Call Radio Flyer Customer Service for additional support.
Loud Noise Produced When Driving| Broken Gearbox| Call Radio Flyer Customer Service for additional support
Defective Wheel| Call Radio Flyer Customer Service for additional support
Parent Remote Control Not Working| Vehicle is Not Turned ON| Make sure vehicle power switch located on the back of the vehicle is “ON.”
 | Parent Remote Control is Not Turned ON| Turn parent remote control “ON” by sliding power switch to “ON” position.
 | Parent Remote Control Out of Range| Bring parent remote control within 60.0 feet (18.3 m) of vehicle. If you are within 60.0 feet (18.3 m) of vehicle and vehicle is not responding, replace remote control batteries.
 | Parent Remote Control Not Paired with Vehicle| To pair Parent Remote Control to vehicle, refer to steps 14 & 15. Call Radio Flyer Customer Service for additional support.
 | Old Battery| Replace parent remote control batteries with 2 new AAA batteries.
 | Defective Parent Remote Control| Call Radio Flyer Customer Service for additional support.

References

• Radio Flyer: Makers of the Little Red Wagon and Tricycle
• P65Warnings.ca.gov
• Radio Flyer: Makers of the Little Red Wagon and Tricycle
• Radio Flyer - Product Registration

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>