Stinger AUDIO DC212D2 Peak Power Car Subwoofer Installation Guide
- June 3, 2024
- Stinger AUDIO
Table of Contents
Stinger AUDIO DC212D2 Peak Power Car Subwoofer
Specifications
| MODEL | DC212D2 | DC212D4 |
|---|---|---|
| Nominal Impedance (Z) | 1.8 ohms | 3.2 ohms |
| DC Resistance (Re) | 3.6 ohms | 6.4 ohms |
| Resonance Frequency (Fs) | 36.2380 Hz | 31.645 Hz |
| Piston Area (Sd) | 0.0471 m2 | 0.0471 m2 |
| Force Factor (BL) | 21.7424 T.m | 27.0326 T.m |
| Mechanical Q Factor (Qms) | 8.9256 | 6.7714 |
| Electrical Q Factor (Qes) | 0.4997 | 0.4433 |
| Total Q Factor (Qts) | 0.4732 | 0.4161 |
| Sensitivity 1W/M (SPL) | 84.9847 | 85.4553 |
| Mechanical Compliance (Cms) | 0.0669 mm/N | 0.0994 mm/N |
| Moving Mass (Mms) | 288.2100 g | 254.5784 g |
| Linear Excursion (Xmax) | 16 mm | 16 mm |
| Volume Acoustic | 20.7705 Ltr | 30.8356 Ltr |
| Compliance (Vas) | 0.734 cu ft | 1.089 cu ft |
| Reference Efficiency (NO.) | 0.19% | 0.21% |
| Nominal Power (Pe) | 1000 Watts | 1000 Watts |
| Peak Power | 1500 Watts | 1500 Watts |
| Frequency Response | 20-200 Hz | 20-200 Hz |
| Voice Coil Diameter | 3 in/76.2 mm | 3 in/76.2 mm |
| Displacement | 0.1083 cu ft/ 3.066 Ltr | 0.1083 cu ft/ 3.066 Ltr |
Dimensions
| Overall Diameter (A) | 12.72in / 323mm |
|---|---|
| Cut Out Diameter (B) | 11.30in / 287mm |
| Mounting Depth (C) | 6.58in / 167 mm |
Enclosure Size (Matters)
Enclosure is the fancy name for a speaker box. You can go ready-made or build your own. Ported or Sealed. To the right are the recommended enclosure size ranges stated in internal volume. Whether buying pre-made or building, try to stay within these parameters for best performance.
| Recommended Sealed Internal Volume | 1.40-2.25 cu.ft. |
|---|---|
| Recommended Vented internal Volume w/o vent displacement | 1.3-3.0 cu.ft. |
| Recommended Vented Area | 23 cu.in. |
| Recommended Tuning Frequency | 30-38 Hz |
Enclosure Example
If you’re going it on your own, here’s a good starting point. We recommend using .75” MDF or plywood. Screws or air staples along with strong bonding “yellow” wood working glue for construction. Be sure that the enclosure’s panels are airtight at all joining seams. Lining the inside with some poly- fill to finish it off.
| External Size | 33″ x 15″ x 14.18″ |
|---|---|
| Material Thickness | 0.75″ |
| Net Internal Volume | 2.75 ft3 |
| Tuning Frequency | 30 Hz |
| Port Area | 22.10 inch2 |
| Port Inlet | 1.64” x 13.50” |
| Port Length | 18.30” |
Material Prep Sheet
| Top / Bottom | 33.00″ x 14.18″ | 2 |
|---|---|---|
| Front | 30.61″ x 13.50″ | 1 |
| Rear | 33.00″ x 13.50″ | 1 |
| Left | 12.69″ x 13.50″ | 1 |
| Right | 13.43″ x 13.50″ | 1 |
| Port 1 | 11.05″ x 13.50″ | 1 |
| Port 2 | 4.12″ x 13.50″ | 1 |
Please note there are no fingers mention in the list above. Cut safe my friends.
Subwoofer Wiring Diagrams
DC2 Subwoofers are Dual Voice Coil (DVC), meaning they have two positive and negative terminals per speaker. The voice coils can be wired in parallel or series or a combination of both. The subwoofer should be wired to match the amplifier’s lowest impedance as stated by the amplifier manufacturer. Going below the amplifier’s minimum impedance may damage the amplifier, so wire carefully. For wiring subwoofers, we recommend using 12- to 16-gauge wire.
WARNING:
Stinger Audio products are capable of producing sound levels that can
permanently damage your hearing! Listen responsibly and avoid continuous
exposure to high sound pressure levels. While driving, keep the volume at a
level that allows you to hear outside warning sounds (sirens, horns, etc.)
LIMITED WARRANTY
Stinger warrants this product to be free of defects in materials and
workmanship for a period of one (1) year from the original date of purchase.
This warranty is not transferable and applies only to the original purchaser
from an authorized Stinger dealer in the United States of America only. Should
service be necessary under this warranty for any reason due to manufacturing
defect or malfunction, Stinger will (at its discretion), repair or replace the
defective product with new or remanufactured product at no charge. Damage
caused by the following is not covered under warranty: accident, misuse,
abuse, product modification or neglect, failure to follow installation
instructions, unauthorized repair attempts, and misrepresentations by the
seller. This warranty does not cover incidental or consequential damages and
does not cover the cost of removing or reinstalling the unit(s). Cosmetic
damage due to accident or normal wear and tear is not covered under warranty.
INTERNATIONAL WARRANTIES:
Products purchased outside the United States of America are covered only by
that country’s Authorized Stinger reseller and not by Stinger. Consumers
needing service or warranty information for these products must contact that
country’s reseller for information.
Please DO NOT return to seller
For help with installation, replacement parts, warranty or returns, please
contact us directly at 727-732-3114 or
[email protected]
Stinger is a Power Brand of AAMP Global
15500 Lightwave, Clearwater, Florida 33760
© 2022 AAMP Global
IG-DC212D REV 052422