CHEFFANO AZ-MG097 Electric Meat Grinder Instruction Manual
- June 16, 2024
- CHEFFANO
Table of Contents
CHEFFANO AZ-MG097 Electric Meat Grinder
SAFETY PRECAUTIONS:
Disclaimer: MEAT GRINDER 120V 60Hz 350W
- This appliance can be used by children age 8 or above and people with reduced physical. sensory or mental capabilities or lack of experience and knowledge only when they have been given supervision or instruction, concerning use of the appliance in a safe way and understand the hazards involved. Children shall not play with the appliance. Cleaning and user maintenance shall not be done by children without supervision.
- For children’s safety, please keep the appliance and its cord out of reach of children.
- Always disconnect the appliance from the supply if it is left unattended or before assembling, disassembling, or cleaning.
When using electrical appliances, basic safety precautions should always be followed, including the following:
IMPORTANT SAFEGUARDS
- READ ALL INSTRUCTIONS BEFORE USING THIS APPLIANCE.
- Keep children away from the machine when in use.
- Do not run the machine unattended.
- Do not use accessories that were not approved by the manufacturer.
- Never operate the appliance with a damaged cord or plug or one that has malfunctioned or been damaged in any way. If necessary, please contact Customer Service for assistance immediately.
- Never use your fingers or other objects to push food through the feed tube. Please use the food pusher.
- Never try to replace the parts or repair the unit by yourself.
- To avoid injury or accident from electrical shock, do not operate the machine with wet hands while standing on a wet surface or while standing in water. Also, do not use the machine outdoors or in wet conditions.
- Do not immerse the machine directly in water to clean it.
- Unplug the cord from the outlet when not in use, before assembling the machine or disassembling the machine, and before cleaning.
- When carrying the unit, please be sure to hold the motor housing with both hands. Do not carry the unit by holding only the hopper plate or head.
- You can not grind bones, nuts, or other hard objects with the machine.
- You can not grind ginger and other hard fiber objects with the machine.
- Do not fix the cutting blade and cutting plate when using a kubbe attachment.
- Operate the appliance on a level surface well away from any hot gas or electrical burner, heat source, combustible spray cans, or pressurized items.
- This machine is for household use only. Do not use it for industrial purposes. Any other use will void the warranty.
- Continuous running of the meat grinder should be not more than 10 minutes.
- Reverse function is prohibited while the appliance is operating (For example switch “REV”), wait at least one minute until grinder has come to a complete stop, otherwise it may cause an abnormal noise, vibration or a transitory electric spark in the appliance. It could result easily damage to appliance.
- Afler use, there would be a little food left in the grinder head. This is normal. There might be a bit of black metal powder adhering to the food ground in the end. Please pick them out and throw away, do not eat them.
- To avoid jamming, do not force to operate the unit with excessive pressure.
- Children or handicapped should be supervised to ensure that they do not play with the appliance.
- WARNING: This product may contain a chemical(s) known to the State of California to cause, birth defects or other reproductive harm.
SAVE THESE INTRUCTIONS!
FOR HOUSEHOULD USE ONLY.
WARNING! This appliance has a polarized plug (one blade is wider than the other). To reduce the risk of electrical shock, the plug is intended to be used by inserting it into the electrical outlet only one way. If the plug doe not fit securely into the outlet, turn the plugand re-insert. Do not modify this plug. If the plug does not fit the outlet securely, call a qualified electrician for assistance. DO NOT use this plug with any kinds of extension cords.
PRODUCT DESCRIPTION
- Food pusher
- Hopper plate
- Grinder Head Release Button
- Body
- ON/OFF button
- REV button
- Grinder Head
- Feed screw
- Cutting blade
- Cutting plate (fine)
- Cutting plate (medium)
- Cutting plate (coarse)
- Fixing ring
- Sausage tube
- Kubbe attachment
BEFORE FIRST USE
- Check that voltage indicated on the rating label corresponds to the mains voltage in your home.
- Wash all parts (except the body) in warm soapy water and dry thoroughly with a dry towel immediately. Do not place parts in the dishwasher or soak them for a long time.
- Before plugging in, ensure the”ON/OFF”switch is turned to”OFF”position.
INSTRUCTION FOR USE
ASSEMBLING
- Holding the head and insert it into the inlet with one hand, revolves toward left. (fig.2)
- Place the feed screw into the head, long end first, by turning the feed screw slightly until it is set into the motor housing. (fig.3)
- Place the cutting blade onto the feed screw shaft with the blade facing the front as illustrated. (fig.4) If it is not fitted properly, meat will not be ground.
- Place the desired cutting plate next to the cutting blade, fitting protrusions in the slots. (fig.5)
- Support or press the centre of the cutting plate with one finger then screw the fixing ring until tight with another hand. (fig.6) Do not over tighten.
- Place the hopper plate on the top of the head and fix into position.
- Locate the unit on a firm place.
- The air passage at the bottom and the side of the motor housing should be kept free and not blocked.
MINCING MEAT
- Cut all foods into pieces that are no larger than 4 inches long or 1/2 inch thick. (Sinewless, boneless and fatless meat is recommended, approximate size: 20 mm x 20 mm x 60 mm) So that they fit easily into the hopper.
- Put the meat on the hopper tray and slowly guide the meat into the head, using the pusher only. (fig.7)
- Place a bowl under the head to collect the minced meat.
- Plug in and turn the”ON/OFF”switch to”ON”position.
- After use, turn off the unit and unplug it from the power supply.
REVERSE FUNCTION
- Firstly, please make sure the machine is off .
- In case of jamming, you can tum the”REV” switch. The feed screw will rotate in opposite direction, and the head will get empty. When you release the “REV” button, the appliance will stop easily.
- Whenyou finish, please tum off the machine and clean it.
MAKING KUBBE
- Feed the prepared kubbe mixture into the heed, gently guiding it with the pusher.
- Plug in and tum on the machine. The mixture is extracted in one continuous supply.
- Cut the mixture into equal parts as it is extruded.
RECIPE FOR STUFFING
- Mutton 100g
- Olive oil 1 1/tablespoons
- Onion (cut finely) 1 1/tablespoons
- Spices lo your taste
- Salt to your taste
- Flour 1 1/tablespoons
- Mince mutton once or twice.
- Fry onion until brown and add minced mutton, all spice, salt and flour.
RECIPE FOR OUTLET COVER
- Lean meat 450g
- Flour 150-200g
- Spices to your taste
- Nutmeg (cut finely) 1
- Powdered red pepper to your taste
- Pepper to your taste
- Mince meat three times and mix all ingredients together in a bowl. Making cover with more meat and less flour creates better consistency and taste.
- Grind the mixture three times.
- Disassemble the components by reversing the steps from (fig.5) to (fig.3) to remove the cutting plate and cutting blade.
- Place kubbe attachments A and B onto the feed screw shaft together, fitting protrusions in Iha slots. (flg.8)
- Screw fixing ring into place until tight. Do not over tighten. (fig.9)
- Make the cyllndrlcal outlet cover. (flg.1 O)
- Form kubbe as Illustrated below and deep hy.
MAKING SAUSAGES
- Before starting, please assemble sausage attachments as following. (fig.11-12)
- Let the sausage casings in warm water for 1 O minutes and then attach the casings to the sausage filling tube.
- Put the meat on the hopper tray and slowly guide the meat into the head by using the pusher.
- Place a bowl under the head to collect the sausages.
- Plug in and turn on the machine. The machine begins to extrude the meat into the sausage casings.
- After use, switch the unit off and unplug it from the power supply.
CLEANING AND MAITENANCE
DISASSEMBLING
- Make sure that the motor has stopped completely.
- Disconnect the plug from the power outlet.
- Disassemble by reversing the steps from 6-1 pictures.
- If the fixing ring is not easily removed by hands, please use tools.
- To remove the cutting plate easily, place a screwdriver between the cutting plate and the head as illustrated and lift it up (fig.13).
CLEANING
- Unplug the machine before cleaning.
- Remove meat and all components. Wash all parts in warm soapy water. Dry them thoroughly with a dry towel immediately.
- Do not place parts in the dishwasher or soak them for a long time.
- Do not immerse the body in water, please wipe it with a soft damp cloth instead.
- The bleaching solution containing chlorine will discolor aluminum surfaces.
- Thinners and petrol will crack or change the color of the unit.
- Wipe all the cutting parts by wet cloth with vegetable oil.
WARRANTY & SERVICE
This Limited Warranty is for one full year from the date of purchase. It’s applicable to the original purchaser only and is not transferable to a third party user. Repair or replacement of defective parts is solely at the seller’s discretion. In the event that repair isn’t possible, the seller will replace the product/part. If product repair/replacement won’t suffice, the seller has the option of refunding the cash value of the product or returned component.
Product defects not covered under the Warranty provisions include normal wear and damage incurred from use or accidental negligence, misuse of instruction specifications or repair by unauthorized parties. The manufacturing company is not liable for any incidental or consequential damages incurred by such circumstances.
HOUSEHOLD USE ONLY
FREQUENTLY ASKED QUESTIONS
What is the brand of the electric meat grinder mentioned in the information provided?
The brand of the electric meat grinder is CHEFFANO.
What is the capacity of the CHEFFANO AZ-MG097 Electric Meat Grinder?
The capacity of the meat grinder is 81 kilograms.
Can you provide the package dimensions of the CHEFFANO AZ-MG097 Electric Meat Grinder?
The package dimensions are 16.38 x 11.75 x 8.5 inches.
How much does the CHEFFANO AZ-MG097 Electric Meat Grinder weigh?
The item weight is 8.98 pounds.
What is the model number of the CHEFFANO AZ-MG097 Electric Meat Grinder?
The model number is AZ-MG097.
Has the CHEFFANO electric meat grinder received any safety certifications, and if so, which ones?
Yes, the meat grinder has received ETL safety certifications.
What accessories are included with the CHEFFANO AZ-MG097 Electric Meat Grinder, and what material are they made of?
The accessories include 3 grinding plates (Diameter: 2mm/5mm/7mm), 2 blades, 1 food pusher, and a set of kubbe and sausage accessories. All accessories are made of food-grade material.
How powerful is the motor in the CHEFFANO AZ-MG097 Electric Meat Grinder?
The meat grinder is equipped with a 100% pure copper motor with a normal rated power of up to 350W and a peak value that can reach up to 2600 watts.
What is the grinding capacity of the CHEFFANO AZ-MG097 Electric Meat Grinder per hour?
The meat grinder can efficiently grind approximately 180 lbs of meat per hour.
What is the update related to the auger in the CHEFFANO AZ-MG097 Electric Meat Grinder?
The meat grinder uses a 3-layers auger design to reduce heat during grinding, preserving nutrition and preventing the formation of gray streaks on minced meat.
What are the benefits of the auger update in the CHEFFANO AZ-MG097 Electric Meat Grinder?
The update helps ensure the freshness of the ground meat and contributes to a healthier outcome for you and your family.
How easy is it to use the CHEFFANO AZ-MG097 Electric Meat Grinder, and what are the operational instructions?
The meat grinder is easy to operate. After assembling the parts, plug in the power supply (Voltage–120V, Frequency–60 Hz), press the on button, and feed the food. The REV button can be used to unclog the unit if something gets stuck.
Is the CHEFFANO AZ-MG097 Electric Meat Grinder dishwasher safe?
No, the meat grinder is not dishwasher safe. It is recommended to wash the attachments by hand with water (under 122°F or neutral detergent), and to keep them dry quickly with a towel.
Is there a warranty for the CHEFFANO AZ-MG097 Electric Meat Grinder, and what does it cover?
Yes, the product comes with a 30-Days Unconditional Money Back Guarantee and a 1-Year Warranty. The warranty includes free replacement of attachments and technical support.
Is there a customer support service for the CHEFFANO AZ-MG097 Electric Meat Grinder?
Yes, there is 24/7 customer support available. If there are any questions or issues, customers can contact the support team.
VIDEO – PRODUCT OVERVIEW
DOWNLOAD THE PDF LINK: CHEFFANO AZ-MG097 Electric Meat Grinder Instruction Manual