AIRTHEREAL AH20K Ozone Generator For Laundry System User Manual

**AIRTHEREAL AH20K Ozone Generator For Laundry System User Manual

**

INTRODUCTION

Congratulations on your purchase and welcome to Airthereal!
To fully benefit from the support that Airthereal offers, please register at www.airthereal.com/register.

HOW DOES AN OZONE GENERATOR WORK FOR THE LAUNDRY SYSTEM?

After the product is properly connected to your washing machine or water tap, it will automatically
work when you turn on the washing machine or the water tap without any other input from you. This
helps reduce the use of laundry detergent. You can use the ozone generator together with laundry
detergent or not.

SAFETY INSTRUCTION

• Do not install the unit in a place where the temperature is higher than 122°F or lower than 32°F.
• Do not install the unit under direct sunlight.
• Disconnect the washing machine power cord before installation.
• Use the attached new hose when connecting the unit to your washing machine.
• Do not mount the product vertically, upside down, or at an angle.
• Water treated by the product is not intended for drinking.
• This product can be used with residential washing machines with a maximum flow rate of 8L/min.
• This device complies with part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) This device may not cause harmful interference, and (2) this device must accept any interference
  received, including interference that may cause undesired operation.

PARTS INTRODUCTION

SPECIFICATION

INSTALLATION

1. Choose a place near a power outlet and your washing machine for installation. The product should be installed 18-20 inches above the washing machine. Do not install it in a place where water may freeze.

2. Place the wall bracket with the slots facing up and out. Use a bubble level to make sure it is horizontal. Mark the screw hole position. Drill holes in the wall and fasten the bracket with anchors and screws.

3. Align the slots on the back of the unit with the bracket. Gently slide the machine down into the locked position of the wall bracket. Make sure the unit is secure

4. Turn off the water to your washing machine.

5. Disconnect the end of your existing water hose (1) from the washer and connect it to the water inlet port of the ozone generator. Tighten the connection but do not over-tighten. Leave the other end connected to your water source. If the existing hose is not in good condition, replace with a new one.

6. Attach one end of the included hose (2) to the water outlet port A of the ozone generator and the other end to the water inlet port of the washing machine. Use pliers to tighten bothends, but do not over-tighten. If there is a hot water hose, leave it as originally installed.

7. You can attach another hose to the water outlet port B if you wish, using ozone-treated water for more other purposes like washing pets.

8. Slowly turn on the water supply and carefully check all connections, ensuring that there are no leaks. If leaks exist, reattach the hose and ensure that the junctions are properly aligned. If the junction continues to leak, use Teflon tape to achieve a tight seal.

9. Plug the power cable into the ozone generator and plug it into the power outlet. When connected, the ozone generator will power on with a beep sound and then enter standby mode. It will automatically work when the washing machine begins to wash.
   

OPERATING INSTRUCTION

After plugging in the unit, there will be a beep sound. This means that the unit is powered on but is in standby mode until the water flow is active. Use COLD water only

After plugging in the unit, there will be a beep sound. This means that the unit is powered on but is in standby mode until the water flow is active. Use COLD water only

especially tough stains, we suggest that you pre-treat stains as you normally would.
Low| Green Light| For normal everyday clothes and mixed color loads. Add a small amount of detergent or none at all.
No Ozone| No Light| Choose to run the washing machine without ozone.

When the water flow stops, the unit will return to standby mode.
NOTE: If you have hard tap water, we recommend installing a refilter directly before the unit tp reserve the service life of your ozone generator and reduce maintenance.

Desiccant Dryer
The Desiccant Dryer is designed to remove moisture from the air flowing into the product, which helps to ensure optimum performance.

• Before use, tear off the sticker on the top of the desiccant dryer.

• When the mode indicator displays red, it is a reminder to replace the desiccant. Use the attached wrench to take out the desiccant in a counter-clockwise direction. Insert a new desiccant pack, ensuring to align the slots and screw it in clockwise. You can feel it stick in place when fully installed.
  

• Press and hold the two Desiccant Reset buttons at the same time for 3 seconds to reset the countdown timer for the desiccant. You will hear a beep sound, then the mode light will turn blue

TROUBLESHOOTING

20-100psi.
If the unit doesn’t beep when connected to power, the power cable is not plugged in or is broken.| Plug in the power cable or use a new one.
There is obstacle stuck in the system.| Swap the water inlet and outlet pipes of the ozone generator and let water flow in the opposite direction for 2 minutes.Reinstall the pipes in the correct way after 2 minutes.
Water is too hot.| Use cold water only between 32oF-122oF.
No ozone smell in the laundry.| Check if the water flow rate is less than 3.5L/min.| The flow rate should be at least 3.5L/min.
Clothes are being bleached.| This may occur when using higher ozone concentration to wash mix-colored clothes.| Use low ozone level to wash those clothes.
**** No/little water comes out.| Multiple appliances are using water at the same time.| Turn off other water appliances.
**** There is an obstacle stuck in the system.| Swap the water inlet and outlet pipes of the ozone generator and let water flow in the opposite direction for 2 minutes. Reinstall the pipes in the correct way after 2 minutes.

LIMITED WARRANTY

Arterial warrants the product for 1 year from the date of purchase. For more information please visit www.airthereal.com/warranty

What’s covered?
Defects due to faulty materials and workmanship of the product

What’s NOT covered?

1. Damage caused by the owner when attempting to fix or altering the product by him or herself.
2. Damage caused by misuse, abuse, neglect, alterations, or unauthorized repair.
3. Natural depreciation

Warranty Period
Warranty becomes effective from the date of original purchase and will last for 1 year

Who’s covered?
This limited warranty is only effective for the original purchaser. It is non- transferable.

How to request warranty services?
To obtain the benefit of this warranty, please email support@airthereal.com. Our customer service team will address your issue as soon as possible!

DISPOSAL OF USED PRODUCT
This product must not be disposed of via normal household waste after its service life but must be taken to a collection station for the recycling of electrical and electronic devices. The symbol on the product,  he operating instructions or the packaging indicate such disposal procedures. The materials are recyclable in accordance with their respective symbols. By means of re- use, material recycling or any other form of recycling old appliances you are making an important contribution to the protection of our environment

Please ask your local council where your nearest disposal station is located.

Keep Out Of Reach Of Children
Produced for: West Ryder Technology LLC
2330 Paseo Del Prado STE C304 Las Vegas, NV 89102
EPA EST NO: 92235-CHN-1
support@airthereal.com

References

• Airthereal - Ozone Generators, Air Purifiers, Water Heaters, Composter
• Airthereal Warranty Registration
• Airthereal Warranty

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>