FISHER PAYKEL CPV3-488 48 Inch Gas Rangetop with Dual Flow Burners User Guide

: June 4, 2024
: Fisher & Paykel

Table of Contents

FISHER PAYKEL CPV3-488 48 Inch Gas Rangetop with Dual Flow Burners
SAFETY AND WARNINGS
BEFORE YOU BEGIN
FIRST USE
GRIDDLE USE
CARE AND CLEANING
TROUBLESHOOTING
WARRANTY AND SERVICE
References
Read User Manual Online (PDF format)
Download This Manual (PDF format)

FISHER PAYKEL CPV3-488 48 Inch Gas Rangetop with Dual Flow Burners

FISHER-PAYKEL-CPV3-488-48-Inch-Gas-Rangetop-with-
PRODUCT

SAFETY AND WARNINGS

Fire Hazard
Failure to follow this advice may result in overheating, burning, and injury.
Never leave the appliance unattended when in use. Boilover causes smoking and greasy spillovers that may ignite.
Cut Hazard
Failure to use caution could result in injury.
Take care: some edges may be sharp.
Take care: some edges may be sharp.
Do not use or store flammable materials such as gasoline near this appliance.
Do not spray aerosols in the vicinity of this appliance while it is in operation.
Poisoning Hazard
Failure to follow this advice may result in carbon monoxide poisoning or overheating.
Never use the appliance as a space heater to heat or warm the room.
Hot Surface Hazard
Failure to follow this advice could result in burns and scalds.
To avoid burns and scalds, keep children away from the appliance.
Surfaces of the appliance may become hot enough to cause burns.
During and after use, do not touch or let clothing or other flammable materials contact cooktop components or burners until they have had sufficient time to cool.

READ AND SAVE THIS GUIDE

WARNING!
To reduce the risk of fire, electrical shock, injury to persons or damage when using the rangetop, follow the important safety instructions listed below. Read all the instructions before use.

Installation

Ensure the appliance is properly installed and earthed by a qualified technician.
Ensure this rangetop is connected to a circuit that incorporates an isolating switch providing full disconnection from the power supply.
Do not install or operate the appliance if it is damaged or not working properly. If you receive a damaged product, contact your dealer or installer immediately.

Servicing

Do not repair or replace any part of the appliance unless specifically recommended in the user guide. All other servicing should be undertaken by a Fisher & Paykel trained and supported service technician or qualified person.

Fire Hazard

Use only dry oven mitts or potholders. Moist or damp potholders on hot surfaces could result in burns from steam. Do not let potholders touch hot areas.
Do not use a towel or a bulky cloth for a potholder. It could catch fire.

General Use

Household appliances are not intended to be played with by children.
Children should not be left alone or unattended in the area where the appliance is in use. They should never be allowed to sit or stand on any part of the appliance.
Children of less than 8 years old must be kept away from the appliance unless continuously supervised.
This appliance can be used by children aged from 8 years and above, and persons with reduced physical, sensory or mental capabilities or lack of experience and knowledge, if they have been given supervision or instruction concerning the use of the appliance in a safe way and they understand the hazards involved. Cleaning and user maintenance shall not be carried out by children without supervision.
Caution: Do not store items of interest to children in cabinets above the rangetop or on. Children climbing to reach items could be seriously injured.
Do not wear loose fitting or hanging garments when using the appliance. They could ignite or melt if they touch a hot surface and you could be burned.
Do not cook on a broken cooktop. Should the cooktop break, cleaning solutions
and spillovers may penetrate the broken cooktop and create a risk of electric shock. Contact a qualified electrician immediately.
Do not place metallic objects such as knives, forks, spoons and lids on the cooktop surface as they can get hot.
Utensil handles should be turned inward and not extend over adjacent surface.

Cleaning and maintenance

Clean only the parts listed in this guide.
Do not use a steam cleaner to clean any part of the rangetop.
Keep appliance area clear and free from combustible materials.

BEFORE YOU BEGIN

Read this guide, taking special note of the ‘Safety and warnings’ section.
Remove all packaging from the cooktop. Recycle responsibly.
Remove any adhesive residue using dishwashing liquid on a soft cloth. Do not use any harsh or abrasive cleaners.

FIRST USE

Control panel

*Using the burner and griddle dials
**

To use the burner and griddle dials, push in and turn counterclockwise to LITE. Hold the dial at LITE before turning to a flame setting.

Dial halos
When a burner in use, a red halo will illuminate. If all dials are turned OFF, all halos will dim.

BURNER USE

Selecting and using burners

Identify the desired burner and the corresponding dial. Push the dial in and turn counterclockwise to LITE. Hold the dial at LITE before turning to a flame setting.
You should hear a clicking sound when setting to LITE. If no clicking sound is present, turn the dial back clockwise to OFF and refer to ‘Troubleshooting’ for advice.
When the burner is lit, turn the dial to any setting between HI (high) and SIM (simmer).
When you have finished cooking, turn the dial clockwise back to OFF. If you are using LP gas, there may be a slight extinction pop or flash at the flame spreader a few seconds after the burner has been turned off. This is normal.

If the flame is extinguished during a power failure, turn the dial back to OFF as the burner will not automatically relight and gas may accumulate.

Manual lighting
If the burner will not light after several attempts, or if there has been a power outage, the burners can be manually lit. If you have attempted to light the burner with the ignition, allow 1 minute for any accumulated gas to dissipate before manually lighting.

Carefully hold a battery operated lighter near the desired burner.
Push the dial in and turn counterclockwise to LITE. Hold the dial at LITE before turning to a flame setting.
When the burner is lit, turn the dial to any setting between HI (high) and SIM (simmer).
When you have finished cooking, turn the dial clockwise back to OFF. If you are using LP gas, there may be a slight extinction pop or flash at the flame spreader a few seconds after the burner has been turned off. This is normal.

Burner output
All burners have the same low turn-down setting (SIM) for gentle simmering (1,300 BTU/hr). Use SIM for melting chocolate and butter, cooking rice and delicate sauces, simmering soups and stews, and keeping cooked food hot.
For cooking that requires intense heat use the burners listed below. These have a higher maximum output than other burners (23,500 BTU/hr for Natural gas, 19,000 BTU/hr for LP gas).
CPV3-485GD models: Center burner
CPV3-488, CPV3-486 and CPV3-366 models: Front left or front right burner
All other models: Front left burner

Use and care

Never leave the cooktop unattended when in use. Boil-over causes smoking and greasy spills that may ignite.
Never allow flames to extend beyond cookware or curl up its sides. This could discolor and damage the utensil and you may get burned touching a hot handle.
Keep handles out of the way. Turn handles so that they don’t extend over the edge of the cooktop or another burner that is on.
Take care when deep-frying. Oil or fat can overheat very quickly, particularly on a high setting.
Make sure that all burner parts are correctly fitted. Incorrectly or incompletely assembled burners may produce dangerous flames. See ‘Replacing burner parts’.
Keep the burners clean. Especially after a spill or boilover, ensure the affected burners are cleaned before using them again. Food residue may clog the ignitor and the notches of the flame spreader, stopping the burner from functioning correctly. See ‘Care and cleaning’ for instructions.
Check that the burner flames are regular. They should be blue with no yellow tipping, and burn without fluttering around the burner cap. If not, see ‘Troubleshooting’ for advice.
Use woks only with a wok ring. Wok rings can be purchased separately through your Fisher & Paykel dealer or Customer Care. To use, place the wok ring over the grates, making sure the small protrusions on its bottom straddle the grate fingers. The wok ring should be stable and unable to rotate.

GRIDDLE USE

FISHER-PAYKEL-CPV3-488-48-Inch-Gas-Rangetop-with-
FIG-7

Push the dial in and turn counterclockwise to the desired temperature. You should hear a clicking sound when setting to LITE. If no clicking sound is present, turn the dial back clockwise to OFF and refer to ‘Troubleshooting’ for advice.
When the burner is lit, turn the dial to any setting between HI (high) and SIM (simmer).
When you have finished cooking, turn the dial clockwise back to OFF. If you are using LP gas, there may be a slight extinction pop or flash at the flame spreader a few seconds after the burner has been turned off. This is normal.

CARE AND CLEANING

ALWAYS

Read these instructions and the ‘Safety and warnings’ section before you start cleaning your rangetop.
Before cleaning or removing any part, make sure that everything on the range has been turned off.
Unless suggested otherwise in the chart following, allow any part to cool to a safe temperature before cleaning. If you do need to handle a warm or hot part take extreme care. Wear long protective mitts to avoid burns from steam or hot surfaces.
Try using any cleaner on a small area first, to ensure it doesn’t stain.
WHAT?| HOW?| IMPORTANT!
---|---|---
Burners| Do not clean these parts. They self-clean during normal use.|
Area around burners| • Soften any stubborn stains using a hot soapy cloth before| • Always read the label to ensure your stainless steel cleaner does
| cleaning with a solution of mild| not contain chlorine compounds
| detergent and hot water. Wipe| as these are corrosive and may
| dry with a microfiber cloth.

• For extra shine, use a suitable stainless steel cleaner. Always

and brass flame spreader and wash

| spreaders clear. Soiling may clog

these and cause ignition problems.

FISHER-PAYKEL-CPV3-488-48-Inch-Gas-Rangetop-with-FIG-8

NEVER

Use aerosol cleaners until the rangetop has completely cooled. The propellant substance in these cleaners could catch fire in the presence of heat.
Let soiling or grease accumulate anywhere on
the rangetop. This will make future cleaning more difficult and may present a fire hazard.
Use any abrasive or harsh cleaners, cloths, scouring pads or steel wool. These will scratch your range and damage its appearance.
Use a steam cleaner to clean any part of the range.
Lift the black grill and griddle frames off the cooktop.

Replacing burner parts
Ensure that all burner parts are correctly fitted. Incorrectly assembled burners may produce dangerous flames. Flames should be blue with no yellow tipping, and burn without fluttering around the burner cap. FISHER-PAYKEL-
CPV3-488-48-Inch-Gas-Rangetop-with-FIG-9

TROUBLESHOOTING

PROBLEM	POSSIBLE CAUSES	WHAT TO DO
The ignitor keeps clicking (continuous spark) even when a burner has lit.
Dirty or wet ignitor(s)	Clean the ignitor(s). See ‘Care and cleaning’ for

guidance.
None of the burners will light.| No power supply| The cooktop burners can still be used. To light them manually refer to ‘Manual lighting’ for guidance.
| No gas supply| Check that the gas supply to the
| | house is working. You should hear
| | the gas when you turn a burner on.
| | If you are using bottled gas, check
| | that it is not empty.
Some burners will not| Burner parts or ignitors may be| Check that the burner parts
light – Flames do not burn all around the burner cap.| wet, dirty, or misaligned.| are clean, dry, and correctly assembled. Ensure the ignitors

are clean and dry. See ‘Care and

relight. However, if there has

WARRANTY AND SERVICE

Before you call for service or assistance Refer to the installation guide and user guide and check that your product is correctly installed and you are familiar with its normal operation. If after checking these points you still need assistance or parts, please refer to the Service & Warranty book for warranty details and your nearest Service Center, Customer Care, or contact us through our website www.fisherpaykel.com